气体静压止推轴承静动态性能及振动抑制

doi:10.13675/j.cnki. tjjs. 180620

推进技术 ›› 2019, Vol. 40 ›› Issue (9): 2091-2098.DOI: 10.13675/j.cnki. tjjs. 180620

气体静压止推轴承静动态性能及振动抑制

张皓成¹,吴志强¹,李跃华²,李亚杰¹,章国齐¹,张祥云¹

1.天津大学机械工程学院，天津 300072;2.天津市微低重力环境模拟技术重点实验室，天津;300301

发布日期:2021-08-15
作者简介:张皓成，硕士，研究领域为非线性动力学设计与控制。E-mail：zhanghaocheng@tju.edu.cn
基金资助:
国家自然科学基金 11672349 11372211;天津市自然科学基金（青年）项目 17JCQNJC04800国家自然科学基金（11672349；11372211）；天津市自然科学基金（青年）项目（17JCQNJC04800）。

Static and Dynamic Characteristics and VibrationSuppression of Aerostatic Thrust Bearing

1.School of Mechanical Engineering，Tianjin University，Tianjin 300072，China;2.Tianjin Key Laboratory of Microgravity and Hypogravity Environment Simulation Technology，Tianjin 300301，China

Published:2021-08-15

摘要/Abstract

摘要： 为探讨抑制气体轴承自激振动的新手段，研究了圆盘形单个小孔节流的气体静压止推轴承振动问题。通过两平行圆盘间的气体流动方程，推导建立了气体轴承静动态特性分析模型。通过数值分析的方法，研究并总结了供气压力和气膜厚度对气体轴承静态承载力、静态气体质量流量、静动态刚度以及动态阻尼的影响，计算得到了一系列气体轴承静动态特性变化曲线。然后针对系统出现负阻尼情况，通过引入非线性能量阱（NES）来抑制自激振动的问题。研究结果表明，提高供气压力可以有效地提高气体轴承的静态性能；气体轴承的自激振动主要源于气膜挤压的负阻尼特性；同时，当NES的阻尼超过临界阻尼时，可以使系统的振动得到有效的抑制。

关键词: 轴承;静态性能;动态性能;非线性能量阱;振动

Abstract: To investigate a new method to suppress the self-excited vibration of gas bearing, the vibration of the disk aerostatic thrust bearing with single orifice compensation was studied. Based on the gas flow equation between two parallel discs, the static and dynamic characteristics analysis models of gas bearing were established. By method of numerical analysis, the effects of gas supply pressure and film thickness were studied and summarized, which included static capacity, static gas mass flow rate, static and dynamic stiffness and dynamic damping of air bearing. By calculating, a series of curves of static and dynamic characteristics of air bearing are obtained. A nonlinear energy sink (NES) was introduced to deal with the self-excited vibration of bearing system which caused by negative damping. The results show that the static characteristic of gas bearings can be effectively improved by increasing the supply pressure. The self-excited vibration of gas bearings is mainly due to the negative damping characteristics of gas squeezing. And the vibration of the system can be effectively suppressed when the damping of NES exceeds the critical damping.

Key words: Bearing;Static characteristics;Dynamic characteristics;Nonlinear energy sink;Virbration

张皓成,吴志强,李跃华,李亚杰,章国齐,张祥云. 气体静压止推轴承静动态性能及振动抑制[J]. 推进技术, 2019, 40(9): 2091-2098.

ZHANG Hao-cheng¹,WU Zhi-qiang¹,LI Yue-hua²,LI Ya-jie¹,ZHANG Guo-qi¹,ZHANG Xiang-yun¹. Static and Dynamic Characteristics and VibrationSuppression of Aerostatic Thrust Bearing[J]. Journal of Propulsion Technology, 2019, 40(9): 2091-2098.

参考文献

[1] 韩东江，杨金福，陈昌婷，等. 轴承供气压力对静压气体轴承-转子系统动力学特性影响的实验[J]. 推进技术， 2014， 35(9): 1265-1270.
[2] Powell J W. Design of Aerostatic Bearings[M]. New York: The Machinery Publishing Co， Ltd， 1970.
[3] 郭良斌，王祖温. 环面节流静压圆盘止推气体轴承的动特性计算[J]. 液压与气动， 2006， (7): 7-11.
[4] Al-Bender F. On the Modelling of the Dynamic Characteristics of Aerostatic Bearing Films: From Stability Analysis to Active Compensation[J]. Precision Engineering， 2009， 33(2): 117-126.
[5] Bhat N， Kumar S， Tan W， et al. Performance of Inherently Compensated Flat Pad Aerostatic Bearings Subject to Dynamic Perturbation Forces[J]. Precision Engineering， 2012， 36(3): 399-407.
[6] Chen X， Ye Y. Influences of the Restrictor Design Parameter and Operating Conditions of Aerostatic Bearings on Its Dynamic Characteristics[C]. Singapore: IEEE/ASME International Conference on Advanced Intelligent Mechatronics， 2009.
[7] Majumdar B C. Dynamic Characteristics of Aerostatic Thrust Bearings with Porous Inserts[J]. Journal of Mechanical Engineering Science， 1980， 22(2): 55-58.
[8] 王云飞. 气体润滑理论与气体轴承设计[M]. 北京: 机械工业出版社， 1999.
[9] Franssen R H M， Potze W， De Jong P， et al. Large Amplitude Dynamic Behavior of Thrust Air Bearings: Modeling and Experiments[J]. Tribology International， 2017， 109: 460-466.
[10] 裴浩，龙威，杨绍华，等. 空气静压轴承微振动形成机理分析[J]. 振动与冲击， 2018， (5): 71-78.
[11] Talukder H M， Stowell T B. Pneumatic Hammer in an Externally Pressurized Orifice-Compensated Air Journal Bearing[J]. Tribology International， 2003， 36(8): 585- 591.
[12] 杜建军，刘暾，张国庆，等. 带有圆周方向均压槽的静压气体止推轴承的气锤自激[J]. 润滑与密封， 2010， 35(1): 9-12.
[13] Vakakis A F， Gendelman O. Energy Pumping in Nonlinear Mechanical Oscillators.II. Resonance Capture[J]. Journal of Applied Mechanics， 2001， 68(1): 42-48.
[14] Vakakis A F. Inducing Passive Nonlinear Energy Sinks in Vibrating Systems[J]. Journal of Vibration & Acoustics， 2001， 123(3): 324-332.
[15] Gendelman O， Manevitch L I， Vakakis A F， al et . Energy Pumping in Nonlinear Mechanical Oscillators， Part I—Dynamics of the Underlying Hamiltonian Systems[J]. Journal of Applied Mechanics， 2001， 68(1).
[16] 张也弛，孔宪仁，杨正贤，等. 非线性吸振器的靶能量传递及参数设计[J]. 振动工程学报， 2011， 24(2): 111-117.
[17] Nucera F， Vakakis A F， Mcfarland D M， al et . Targeted Energy Transfers in Vibro-Impact Oscillators for Seismic Mitigation[J]. Nonlinear Dynamics， 2007， 50(3): 651-677.
[18] Carfagno S P， Mccabe J T. Summary of Investigations of Entrance Effects in Circular Thrust Bearings[R]. NASA-CR-67177， 1965.
[19] Holster P L， Jacobs J A H. Theoretical Analysis and Experimental Verification on the Static Properties of Externally Pressurized Air-Bearing Pads with Load Compensation[J]. Tribology International， 1987， 20(5): 276-289.
[20] 孔中科. 气体静压轴承气锤振动机理分析与实验研究[D]: 北京：中国工程物理研究院， 2013.

气体静压止推轴承静动态性能及振动抑制

Static and Dynamic Characteristics and VibrationSuppression of Aerostatic Thrust Bearing

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价